Product ID:CALLA 800
MSDS Date:07/07/1993
FSC:6850
NIIN:01-192-1776
Kit Part:Y
MSDS Number: BTNBZ

ZIP-CHEM PRODUCTS (CALLA)

1860 DOBBIN DR
SAN JOSE, CA 95133
US

Emergency Phone: 800-424-9300

Info Phone: 408-729-0291

Preparer: SAIFI RANIWALA

Cage: 0GUK5

ANDPAK-EMA INC, ZIP-CHEM PRODUCTS DIV

MORGAN HILL, CA 95037 US

Telephone: 408-782-2500/ 800-646-2661

Cage: 8E913

SODIUM HYDROXIDE, CAUSTIC SODA, LYE

CAS: 1310-73-2

RTECS: WB4900000

Fraction By Weight: <5%

OSHA PEL 2 MG/CUM

ACGIH TLV: 2 MG/CUM CEILING

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

DIPROPYLENE GLYCOL METHYL ETHER, DOWANOL DPM, DIPROPYLENE

CAS: 34590-94-8

RTECS: JM1575000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM SKIN

ACGIH TLV: 606 MG/CUM

AMMONIUM HYDROXIDE, AQUA AMMONIA

CAS: 1336-21-6

RTECS: BQ9625000

Fraction By Weight: <5%

ACGIH TLV: 25 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

0.43 LB/GL (51 G/L)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: HIGH CONCENTRATIONS OF
VAPOR MAY CAUSE IRRITATION OF RESPIRATORY TRACT. SKIN: LIQUID
CONTACT CAN CAUSE IRRITATION, ABSORBTION MAY CAUSE BURNING
SENSATION, CONTACT DERMITITIS. EYES: MILD IR RITATION & REDNESS.
INGESTION: HARMFUL.CONTACT W/AMMONIUM HYDROXIDE CAUSES SEVERE
SKIN/MUCOUS MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, BURNING SENSATION.
Medical Cond Aggravated by Exposure:CENTRAL NERVOUS/CARDIOVASCULAR
DISEASES.

First Aid:INHALATION: REMOVE TO FRESH AIR, KEEP PERSON CALM, GIVE
OXYGEN IF NEEDED. SKIN: FLUSH W/WATER, TREAT FOR FROSTBITE IF
NEEDED. EYES: IMMEDIATELY FLUSH W/PLENTY OF COLD WATER. INGESTION:
NOT CONSIDERED A POTENTIAL ROUTE OF EXPOSURE. OBTAIN MEDICAL
ATTENTION IN ALL CASES. NOTE TO PHYSICIANS: CATECHOLAMINE DRUGS
SHOULD BE USED W/SPECIAL CAUTION IN SITUATIONS OF EMERGENCY LIFE
SUPPORT.

Flash Point Method:TCC
Flash Point:>200F
Lower Limits:1.1
Upper Limits:27
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
APPROPRIATE FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:STANDARD TECHNIQUES FOR FIRES INVOLVING THIS
MATERIAL. MATERIAL ITSELF IS NON-FLAMMABLE.
Unusual Fire/Explosion Hazard:DECOMPOSITION MAY OCCUR.

Spill Release Procedures:VENTILATE AREA. DON'T FLUSH INTO SEWERS.
REMOVE OPEN FLAMES. USE SCBA FOR LARGE SPILLS.

Handling and Storage Precautions:DON'T STORE >120F. DON'T STORE/USE
NEAR HEAT, SPARKS, FLAMES. STORE OUT OF REACH OF CHILDREN.
Other Precautions:AVOID BREATHING VAPORS. VAPORS ARE HEAVIER THAN AIR &
WILL COLLECT IN LOW AREAS/OTHER CONFINED AREAS. DON'T GET IN EYES
OR ON SKIN. DON'T TAKE INTERNALLY.

Respiratory Protection:SCBA IF WORKING IN AREA W/EXTREMELY HIGH VAPOR
CONCENTRATIONS.
Ventilation:LOCAL/MECHANICAL RECOMMENDED
Protective Gloves:BUTYL LINED RECOMMENDED
Eye Protection:CHEMICAL GOGGLES
Work Hygienic Practices:USE GOOD HYGIENIC PRACTICES WHEN DEALING WITH
THIS PRODUCT.
Supplemental Safety and Health

Boiling Pt:B.P. Text:212F
Vapor Density:>1
Spec Gravity:1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID W/SLIGHT AMMONIA ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAMES & HIGH TEMPERATURES.
Hazardous Decomposition Products:CO

Waste Disposal Methods:RECLAIM BY DISTILLATION/REMOVE TO A PERMITTED
WASTE FACILITY IAW/FEDERAL/STATE/LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.